Parental Note: This experiment is geared towards ages 7 and up.  The project may require support from an adult to gather materials and also to use a box cutter or x-acto knife.

Experiment Overview:

Solar energy is energy from the sun. Solar energy is a renewable resource because it is a source that replenishes naturally and will always be available to us. Earth receives more energy from the sun in one hour than our entire planet uses throughout an entire year. You may have learned in the solar nightlight experiment that you can use energy (heat) from the sun to power electronic devices by directing light through a solar cell. You can also use the energy emitted by the sun to trap heat and use it to cook food.

In this experiment, we are going to create a homemade oven that uses energy from the sun, rather than electricity, to heat foods to about 200°F. This is a great temperature for reheating leftover pre-cooked foods such as pizza. You can also use your homemade oven to melt cheese for nachos or to make delicious s’mores!

Experiment Materials:

  • Pizza box
  • Aluminum foil
  • Plastic wrap
  • Clear tape
  • Sharpie marker
  • Box cutter or x-acto knife
  • Ruler
  • Glue
  • Plastic straw or chop stick
  • Black paper or felt

 

Experiment Process:

marker and pizza box

Step 1

Use a ruler and a black marker to draw a square on your pizza box lid. The square should have a 1 inch border from the edge of the pizza box.

Step 2

With adult assistance, use a box cutter or x-acto knife to cut out three sides of the square, leaving the edge of the square along the back edge of the pizza box lid attached. Close the pizza box lid and fold back the flap.

pizza box with foil

Step 3

Glue aluminum foil to the inside of the flap and smooth out wrinkles and creases. The foil will reflect sunlight into the pizza box. Carefully cut of any excess foil, being careful not to rip it.

plastic over box

Step 4

Cut out a square of clear plastic wrap that is larger than the flap. Open the pizza box and tape the plastic to the underside of the flap opening. Be sure to pull the plastic wrap taught before taping it down.

box with tape

Step 5

Cut a second piece of plastic wrap and tape to the top side of the flap opening. This will create a window that lets light through but keeps heat trapped inside. Ensuring that your pizza box is airtight is an important step!

foil glued to pizza box

Step 6

Glue a layer of aluminum foil to the bottom of the inside of the pizza box. This will help to insulate your homemade oven.

box with black paper

Step 7

Glue black construction paper or felt on top of the aluminum foil on the bottom of the inside of the pizza box. Black surfaces absorb more heat.

box with foil and paper

Step 8

Glue aluminum foil to all of the inside edges of your oven for even better insulation.

box being used

Step 9

Go outside and find a good spot with full sunlight to use your oven. Adjust the angle of the flap to find the best sun angle for your pizza oven. Cut a plastic straw or wooden chop stick to prop up the flap at the angle you have chosen. Preheat your oven for 30 minutes by letting it sit in the sun and get warm.

Step 10

Heat your food. Place a slice of leftover pizza or other food (ask an adult for suggestions) into your oven in a heat-safe container. Place food items in the center of the oven under the plastic wrap window, close the lid and leave the flap propped up at the optimal angle. Check on your food every 15 minutes until it is ready to eat!

Conclusions:

Solar energy is a renewable resource that humans can access and use from most locations on the surface of the Earth. Now that you’ve made your oven, it is simple to use it again and again whenever the sun is shining. You can use your homemade solar oven to heat up food on camping trips, during power outages or even on a regular day just to save electricity at home.

Extension:

The more airtight your oven, the less hot air will escape, which will let your food cook faster. If you want to make an even higher quality homemade solar oven, try using a bigger box with a removable lid as the outside of your oven, and place a slightly smaller box inside of the big box. You can fill the gaps between the small and big box with newspaper for extra insulation. Then you will line the inside of the small box with tinfoil and glue black paper to the bottom. You can cut out a small square in the lid of the big box and cover it with plastic wrap.

Want to learn more about Community Solar?

Our solar specialists can provide a free consultation.

Get Started